post01

school fuel vapor vacuum water tube boiler

Purchased equipment: school fuel vapor vacuum water tube boiler
Location: WUXI China
Telephone: +86 13861509127
E-mail: lexie@zozen.com
Contact us for more details about our boilers, solutions and services.

High quality aluminum silicate fiber is used with fire clay insulation, to control the boiler body temperature below 45℃ and reduce heat lost.Sufficient steam storage room and heating area to generate high quality steam and high thermal power.Condenser is added to recycle the waste heat of the exhausted smoke to increase feeding water’s temperature and reduce flue gas emission temperature and increase the thermal efficiency over 98% and save operating cost.

Environmental protection

Big combustion chamber equipped with Low emission combustion burner effectively reduce the NOx to 30mg/m3. Smoke duct and smoke outlet use internal insulation to reduce operating noise.

Combustion chamber uses full membrane water cooling wall structure and pressurized combustion without smoke mixture.

Energy conservation

Good quality alumina silicate fiber and fire clay insulation material are used and the boiler body temperature is controlled below 45℃ and greatly heat loss is reduced. Combustion chamber is designed with narrow distance tube membrane water cooling wall which has good air proof to reduce heat lost and increase boiler thermal efficiency. Internal inspection holes uses high-alumina refractory and manhole cover seal devices, solving superheat problem in this part caused by using refractory bricks.

CNC manufacturing technology

The key processing technologies such as steel plate blanking, circling, drum and tube plate drilling adopt advanced CNC machining to reduce the assembly stress and prolong the service life of the boiler.

Steel tube cutting, thread tube pressing and convection tube processing all adopt advanced CNC technology.

Automatic production line.

Leave a Comment

pro_first

Steam Boiler Quiz 3 - ProProfs Qu

A boiler is a closed vessel in which water is transformed into steam under pressure by the application of heat.

Waste Heat Recovery | Heat Exchanger | Heat Pu

Economiser In case of boiler system, economizer can be provided to utilize the flue gas heat for pre-heating the boiler feed water. On the other hand, in an air pre-heater, the waste heat is used to heat combustion air. In both the cases, there is a corresponding reduction in the fuel requirements of the boiler. A economizer is shown in Figure 8.8.

Industry Fuel Hot Water Normal Pressure Fire Tube Boile

3.The horizontal coal-fired atmospheric hot water boiler adopts a three-return water-fire tube structure with a single drum longitudinally arranged. rice mill, garment factory, utility or power plant, hospital, hotel, etc. The relevant capacity hot water boiler is widely used in industry and heating for civil use. the fuel is, the . Live Chat →

RULES AND REGULATIONS FOR BOILER AND PRESSURE VESSE

(b) High Pressure, High-Temperature Boiler - A boiler in which water, oil, or other fluid is heated and intended for operation at pressures in excess of l60 psi and/or tem peratures in excess of 250 degrees Fahrenheit. (c) Heating Boiler - A steam or vapor boiler operating at a pressure not exceeding l5 psi steam pressure or

Boiler System Effi ciency - ReVision Ener

most newer institutional projects are hot water heated. A typical building heating system may not exist, but one possibility might look like Figure 1 and include: • Hot water boilers (may be sectional cast-iron, fi re tube, water tube, etc.); • Natural draft or forced draft burners; • 180°F to 200°F (82°C to 93°C) boiler operating

Pumping Fuel and Fuel Oil - Pump Scho

fuel oil the vacuum reading at the pump should the are #6 fuel oil under the worst conditions (i.e., highest viscosity and lowest liquid The vapor pressure of #2 fuel oil is less than 0.1 PSI (0.0069 BAR) at This document is just for general information purposes. The internet is a great

Glossary Of Boiler Terms - Chemical Publishi

Glossary Of Boiler Terms A ABSOLUTE PRESSURE - Pressure above zero pressure; the sum of the gauge and atmospheric pressures. ACCUMULATOR - (STEAM) A pressure vessel containing water and/or steam, which is used to store the heat of steam for use at a late period and at some lower pressure.

coal fired hot water boiler - coal fired hot water boiler for sal

Atmospheric Pressure Hot Water Boiler Product Description Product Name Oil Hot Water Boiler Fuel Type DZL Single Drum Water-fire Tube Coal Fired Hot water

Vacuum Hot Water Heating Boiler--Z

Vacuum hot water boiler is absolutely safe and is praised as the boiler without explosion forever because it operates in the negative pressure. During the operation process of the boiler, the hot media (water in boiler) doesn’t make any change; it only stays in the vacuum chamber and transfers heat between heat-exchanging tube and heat exchanger.

Foam Products Fuel Vapor Vacuum Water Tube Boil

Foam Products Fuel Vapor Vacuum Water Tube Boiler. WATER-TUBE BOILER A boiler in which the water or other fluid flows through the tubes and the products of combustion surround the tubes. This kind of boiler is mainly used for high pressure steam but also can be used to produce low pressure steam.

Metallurgy Fuel Vapor Vacuum Water Tube Boiler Pri

Is the ratio of the mass of water-vapor in air and the mass of air if it is saturated is called: a. Humidity ratio b. Mass ratio Fuel valve open too long b. High compression pressure c. Carbon in exhaust pipe d. Overload on engine in a water tube boiler, the water will pass through _____ a. inside the tubes b. outside the tubes. Live Chat →