post01

coal fired condensing steam generator

Purchased equipment: coal fired condensing steam generator
Location: WUXI China
Telephone: +86 13861509127
E-mail: lexie@zozen.com
Contact us for more details about our boilers, solutions and services.

High quality aluminum silicate fiber is used with fire clay insulation, to control the boiler body temperature below 45℃ and reduce heat lost.Sufficient steam storage room and heating area to generate high quality steam and high thermal power.Condenser is added to recycle the waste heat of the exhausted smoke to increase feeding water’s temperature and reduce flue gas emission temperature and increase the thermal efficiency over 98% and save operating cost.

Environmental protection

Big combustion chamber equipped with Low emission combustion burner effectively reduce the NOx to 30mg/m3. Smoke duct and smoke outlet use internal insulation to reduce operating noise.

Combustion chamber uses full membrane water cooling wall structure and pressurized combustion without smoke mixture.

Energy conservation

Good quality alumina silicate fiber and fire clay insulation material are used and the boiler body temperature is controlled below 45℃ and greatly heat loss is reduced. Combustion chamber is designed with narrow distance tube membrane water cooling wall which has good air proof to reduce heat lost and increase boiler thermal efficiency. Internal inspection holes uses high-alumina refractory and manhole cover seal devices, solving superheat problem in this part caused by using refractory bricks.

CNC manufacturing technology

The key processing technologies such as steel plate blanking, circling, drum and tube plate drilling adopt advanced CNC machining to reduce the assembly stress and prolong the service life of the boiler.

Steel tube cutting, thread tube pressing and convection tube processing all adopt advanced CNC technology.

Automatic production line.

Leave a Comment

pro_first

Experiences with Coal fired USC Boilers in Denmark - B

the steam characteristics has been in a step-by-step mode. This was done to make sure the availability and reliability of these units were maintained at a high level. 3. Design features of the BWE USC boiler The BWE coal fired USC boiler was developed from the beginning of the 1980s based on existing advanced sub critical design.

Energy Balance of a Coal-Fired Power Plant in Condensin

a steam turbine with reheating, steam , generator regenerative feed water heaters, condenser, feed water, condensate and drain pumps and other necessary related equipment. K 200-130-1 steam turbine is a condensing type turbine and was designed to operate at 3,000 rpm, 13 MPa, and 545 °C with one steam reheat to a

shanghai boiler | China Steam Boiler Suppli

boilers biomass or coal fired boilers condensing oil boiler boiler efficiency vas cost of steam tt boilers nor ab&co thermal transfer case wood boilers for greenhouses

Computational of Pulverized Coal Fired Boiler

Steam boiler is used for heating, gelatinization, and saccharify, etc. Heating equipment is equipped under mash kettle, and then steam produced by Computational of Pulverized Coal Fired Boilers enter into the heating equipment, and then heat the raw materials for starch hydrolysis.

Coal Fired Plants: Horizontal Boilers Make 700C Steam Econom

izontal coal fired boiler for which very considerable cost reductions are claimed, particular-31m 63m 91m Tower Two pass Horizontal Figure 5. Mass flow distribution, steam quality and temperatures in the HRSG for the Cottam combined cycle plant Figure 6. Size comparison of coal fired boilers for 550 MW output Figure 7.

Combined Heat and Power Technology Fact Sheets Serie

a boiler or heat recovery steam generator (HRSG). Unlike gas turbines or microturbines, steam applications are classified as either non-condensing or extraction. A non-condensing turbine, also referred to as a backpressure 9 ystem #1 is relatively small and would typically not be integrated with a coal fired S boiler. Emissions for

Efficiency Assessment of Condensing Steam Turbi

type steam generator, a once-through coal-fired boiler [8]. Fig. 1. Schematic diagram of 200 MW unit [8] Construction of the steam generator is carried out in two distinct bodies, symmetrical with the axis of the group, operating in parallel to the K-200-130-1 steam turbine. The steam output of generator (one

Coal Fired Steam Boiler - steam-generator.c

DZL type coal fired steam boiler is a horizontal three return fire tube and water tube type boiler. There are two fire tubes in the boiler barrel , with both sides light pipe water-wall tubes; DZL coal fired boiler is widely used in textile industry, chemical industry, hospital, school.

Cogeneration Unit: Condensing & Extracting Steam Turbin

Turbine, Turbine Generator, Steam Turbine Generator manufacturer / supplier in China, offering Cogeneration Unit: Condensing & Extracting Steam Turbine Power Plant Contractor, Power Plant Spare Parts Service, on-Grid and off-Grid Solar System and so on.

Boiler (Steam Generator) - Coal Fired Power Plan

A boiler or Steam Generator (prime mover) is an integral device in a fossil fuel power plant used to produce steam by applying heat energy to water. A boiler incorporates a furnace in order to burn the fossil fuel (coal, gas, waste etc.) and generate heat which is transferred to water to make steam.

China Vertical Gas-Fired Condensing Steam Generato

Gas-Fired Condensing Steam Boiler, Gas-Fired Condensing Steam Generator, Gas Steam Boiler manufacturer / supplier in China, offering Vertical Gas-Fired Condensing Steam Generator, Wns 3 Pass Fire Tube Industrial Horizontal Oil Gas Fired Hot Oil Boiler, 3X5m Glass Autoclave for Glass Laminating Production and so on.